Banned in Bikini Bottom/Stanley S. SquarePants - S5-E20
Continuity mistake: Stanley S. SquarePants: When SpongeBob introduces Squidward to his cousin, Squidward's moai house has a doorknob at the right side of the door, but when Squidward loads the back of the moving truck the doorknob is at the left side of the door. (00:14:15)
Banned in Bikini Bottom/Stanley S. SquarePants - S5-E20
Continuity mistake: Banned in Bikini Bottom: After the chief of police tells his wife that he's starving he speeds off, and when it cuts to a closeup of the lock and chains, the wood plank directly behind the chains is crossed from upper right to lower left, but in the next shot it's crossed the opposite way. (00:05:40)
Welcome to the Chum Bucket / Frankendoodle - S3-E2
Continuity mistake: The pencil's length in 'Frankendoodle' varies in between above and beneath the water surface.
House Fancy/Krabby Road - S6-E1
Continuity mistake: Plankton's size changes drastically throughout Krabby Road. Plankton can be seen as reaching up to Spongebob's waist at one point. When he's clutching to the neck of a guitar, the amount of frets that go into his height change between one, two, three, and five, depending on the shot. (00:02:10)
Continuity mistake: When Mr. Krabs and SpongeBob are standing in front of the bomb after it lands but doesn't go off, the clock inside Mr. Krabs' office can be seen from the kitchen. The time on the clock is 5:00, but in the next shot, the time on the clock is suddenly 3:00. The bomb is then revealed to be a mechanical hand, and the time on the clock is now 5:00 again.
Continuity mistake: When SpongeBob accidentally reveals the location of the formula, Plankton drops the feather he is holding and lands in front of him. The feather remains on the floor, but when Pearl walks into the kitchen, the feather has suddenly vanished, and reappears in front of Plankton in the next shot.
Continuity mistake: When Plankton is telling Karen, "There's a whale in the laboratory," he is jumping up and down with his arms in the air, but in the next shot, his arms are suddenly down at his side.
The Inmates of Summer/To Save a Squirrel - S5-E15
Continuity mistake: In "The Inmates of Summer", the campers that board the boat while Spongebob and Patrick are crying together throw confetti that lands on top of their puddle of tears. When the inmates start boarding in a few shots, a wide shot shows the confetti has disappeared and the next shot, which is closer, also shows the confetti to have vanished.
The Inmates of Summer/To Save a Squirrel - S5-E15
Continuity mistake: In "To Save a Squirrel", Sandy has oil stains all over her suit from working on her vehicle. After she is tackled by Spongebob and Patrick when they were chased by a grasshopper in two shots, the stains disappear.
The Inmates of Summer/To Save a Squirrel - S5-E15
Continuity mistake: In "To Save a Squirrel", Spongebob is slowly losing his mind in the mud replica of the Krusty Krab and he begins to make a fake Krabby Patty out of mud. He says he needs buns and suddenly two pieces of rock appear next to him that weren't there before.
Jellyfishing / Plankton! - S1-E3
Continuity mistake: In "Jellyfishing", Patrick and Spongebob slide down two ropes and burn their hands on them. The two shots after they land show them trying to cool down their hands and in the shot after that, the ropes they had just slid down on have disappeared.
Banned in Bikini Bottom/Stanley S. SquarePants - S5-E20
Continuity mistake: In Stanley S. Squarepants, when Squidward moves out of the house with all his bags he doesn't shut the door, but when the shot zooms out, it's shut.
Continuity mistake: In "Once Bitten", Mr. Krabs is holding a key, about to unlock the doors to the Krusty Krab, when a customer stops him. Two shots later, the key is missing from his hands.
Krusty Towers/Mrs. Puff, You're Fired - S4-E9
Continuity mistake: When the rocks fall out of Patrick's suitcase, the rocks change number and position between the 3 shots.
Continuity mistake: When SpongeBob scrambles into the Krusty Krab to tell Mr. Krabs the "good news", the doors swing wildly inward. When the two return outside and see the Flabby Patty, the doors have varied from being open inward, to being open outward.
Atlantis SquarePantis - S5-E12
Continuity mistake: When Patchy finds Encino to have shrank, he hits his peg leg against his foot. When Encino is being turned back into normal, he is wearing shoes on both feet.
Atlantis SquarePantis - S5-E12
Continuity mistake: When Plankton is placed in a jar, there is a sign that says "No Flash Photography" above him. In the next shot, this sign disappears.
A Flea in Her Dome / The Donut of Shame / The Krusty Plate - S5-E11
Continuity mistake: In "A Flea in Her Dome", Patrick asks Spongebob to get on Sandy's shoulders. Then, he climbs onto Spongebob's shoulders. In the next shot, they are suddenly next to Sandy's tree.
A Flea in Her Dome / The Donut of Shame / The Krusty Plate - S5-E11
Continuity mistake: In "A Flea in Her Dome", Patrick gets bitten by a flea and his chest is covered in bites. He takes out a pencil and connects some of the dots to make a horse. A few shots later, the horse and the bites disappear.
Patrick-Man!/Gary's New Toy - S9-E2
Continuity mistake: In "Patrick-Man", in the scene after Mrs. Puff gets arrested, the guy that SpongeBob serves the krabby patty to in the Krusty Krab is not wearing a T-shirt until the guy says "Lets hope Patrick Man doesn't confiscate this one," then he is seen wearing a white T-shirt. (00:08:00)
Chosen answer: You need to provide a little bit more information to be able to answer a question like this. In what region is it not being shown? I see it being replayed here in Australia fairly frequently. As for a general reason, there does not appear to be any for why it specifically might have been taken off the air in any country or region. Like any show certain episodes can sometimes not be replayed for long periods for unknown reasons.
Lummie ★