Continuity mistake: When Kim waits as Teri is getting raped, she changes shoes from one scene to the next. First she's wearing flats, then wedge sandals.
Revealing mistake: Bad guy is shot but can be seen breathing afterwards on the ground. At the start of the next episode, he was shown to be shot in the head. (00:40:38)
Continuity mistake: The clock just tells the viewer that it is 4:40am. Sen. Palmer interrogates his son about the rape of his daughter. In the room, there is a clock that shows 4:57am instead. (00:27:43)
Day 5: 1:00 AM - 2:00 AM - S5-E19
Factual error: When Chloe is at Bill's, she brings up the details of the diplomatic flight, and it shows the aircraft as a Boeing 757-200. This is a twin-engine aircraft, but the one shown is a tri-jet.
Day 6: 8:00 AM - 9:00 AM - S6-E3
Visible crew/equipment: After Tom tells President Palmer that Sandra has been arrested, when it cuts to the interior shot inside the car with Agent Samuels in the front passenger seat, the camera pans toward the rear passenger window showing all the protesters outside. In this shot there's a reflection of the camera operator's leg, wearing shorts, white socks and sneakers, and who is sitting where Sandra should be.
Day 6: 8:00 AM - 9:00 AM - S6-E3
Visible crew/equipment: When Jack pulls over at the side of the road, as he informs Curtis that Assad is two miles ahead on the service road, the red T-mark is visible on the ground where the two men will stand.
Day 8: 7:00 A.M. - 8:00 A.M. - S8-E16
Character mistake: When the exit guard puts Dana Walsh's ID card in the computer it comes up with "apprenhend on site", which should obviously be "apprehend on sight". (00:09:45)
Day 6: 3:00 PM - 4:00 PM - S6-E10
Visible crew/equipment: While Bill, Nadia, and others begin watching Turner's team move toward Gredenko's presumed location on the live video feed, in the next shot facing Bill and Nadia, the T-mark quickly becomes visible at the bottom of the screen, near Bill's feet. (00:29:50)
Day 7: 9:00 AM - 10:00 AM - S7-E2
Visible crew/equipment: While FBI agents are searching for the sniper Jack tells Renee there must be a bad agent, and just as he warns her about who she lets in, the green T-mark is visible on the ground. (00:05:35)
Day 6: 12:00 AM - 1:00 AM - S6-E19
Visible crew/equipment: After Tom tells the VP that he could authorize ancillary agencies to join the search to find Jack, he and Karen leave the Oval Office, and in the next shot facing Lisa as she walks toward Noah, the yellow T-mark is visible on the rug at the bottom of the screen. (00:11:05)
Day 6: 12:00 PM - 1:00 PM - S6-E7
Continuity mistake: At the very end of the previous episode (approx 11:59 AM), Jack and Phillip are chained at the back of the van, and in the closeup Jack's handcuff double bar faces up on his right wrist. This moment is shown in the recap at the start of this episode. When the van reaches the dump site (approx 12:07 PM), Jack and Phillip are unchained and now Jack's handcuff single bar faces up on his right wrist. (00:01:55 - 00:07:55)
11:00 A.M.-12:00 Noon - S1-E12
Continuity mistake: When fleeing from the compound, Kim wears running shoes instead of the wedge sandals (or the flats she wore when Teri was raped).
Day 4: 1:00 A.M.-2:00 A.M. - S4-E19
Continuity mistake: At the very end of Episode 18, Jack knocks out Joe Prado after breaking his thumb and getting information from him. At the very beginning of Episode 19, we see Prado already being treated for his injuries, with a hand splint, and nurses checking his head, within the CTU clinic. Even if you factor in the opening recap sequence at the beginning of every episode, that means that Joe Prado regained consciousness, Jack unhooked his handcuffs, and dragged him back to CTU in three minutes or less.
12:00 Midnight-1:00 A.M. - S1-E1
Continuity mistake: When Kim is sitting on the roof of the furniture store she is looking straight ahead. However the camera changes and now she is looking down. (00:18:05)
12:00 Midnight-1:00 A.M. - S1-E1
Visible crew/equipment: Jack pulls up next to a bus on his way to CTU. As he drives off the camera reflection can be seen in the window of the car. (00:09:10)
12:00 Midnight-1:00 A.M. - S1-E1
Visible crew/equipment: When Rick leads Kim into the store, as the door closes so a large white stage light or light screen is reflected in the door. (00:12:05)
12:00 Midnight-1:00 A.M. - S1-E1
Continuity mistake: Janet jumps up on a table at the furniture store and is joined by a bloke who proceeds to have a drink from a can of beer. The camera does a quick cut and the drinker's position has completely changed. (00:12:30)
12:00 Midnight-1:00 A.M. - S1-E1
Visible crew/equipment: When Terri stands up to go and talk to Kim with Jack at the start the camera pans too far to the left and part of the filming equipment is visible in the shot. (00:05:35)
12:00 Midnight-1:00 A.M. - S1-E1
Visible crew/equipment: When Jack drives off in his car to go to CTU, as the car drives off a stage light is reflected in the cars paintwork. (00:08:05)
12:00 Midnight-1:00 A.M. - S1-E1
Continuity mistake: When we first see Jack he has his hand up by his mouth and then by his chest. When the camera changes to show Kim, his hand is now lowered. (00:03:30)